Replacement Battery for Roomba 500, 600, 700, & 800 Series

The very latest news and updates for the iRobot Roomba robotic vacuum, the Scooba Robotic Washer and the Dirt Dog workshop sweeper. All discussion and troubleshooting questions go here.

Replacement Battery for Roomba 500, 600, 700, & 800 Series

Postby Tenergy » December 28th, 2016, 7:37 pm

UPDATES:

The latest Lithium version is now open for product focus group! Please email us if you would like to sign up for a FREE sample (U.S. only).

It has come to our attention that some customers are experiencing Error 5 with this lithium version.

We would like to provide troubleshooting tips here:
1. Once the battery is fully charged, it's not recommended to remove & re-charge again immediately
*Either activate the roomba device, leave charger off, or continually keep it charging

2. Re-Charging a full a battery may result in an Error 5.
*In the event an Error 5 occurs (related to a fully charged battery) use it for 10 minutes or more and proceed to recharge the battery - the error message will disappear.

Amazon Link: https://www.amazon.com/dp/B00NBAV8DY

Image
Image


----------------------------------------------------------------------------------------------------------------------------------------
Hey Guys!

We are running an online focus group for our replacement battery for Roomba 500, 600, 700, & 800 series: Amazon Link.
If any of you would like to receive this battery for free (U.S. only) and give your Roomba a boost, please PM or email me.

In exchange we would like to learn about your thoughts on the battery. Any feedback would be much appreciated!

Happy holidays!

Tenergy Team

Image
Image
Last edited by Tenergy on March 17th, 2017, 7:36 pm, edited 2 times in total.
Tenergy
 
Posts: 3
Joined: December 21st, 2016, 10:23 pm
Location: California, USA

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby a1robotrepair » December 29th, 2016, 9:18 pm

Verified: Tenergy Corperation
436 Kato Terrace
Fremont, CA 94539
I am going to test their 4500 mAh rated R3 battery. That's a lot of juice for a little SC cell.

Initial:
27.1 oz heavy battery, 14.4K on T IR temp 17.48, 15.8V, could be shrink wrapped better around directional tab.
In Test Robot: +1 to m flow, 20m@22C amb.
540 081023 2012-03-22-1549, 19.4C, 15.6 to 16.1V @ 1.26A, 400mO pack, 33/cell, state 5
110m to 17.5V dTdt, 17.0 @ delta, 40.9C, 400 & 33, state 6
230m, 16.5V, 50mA, 36C, state 7, large mass packs cool slower
Bbox@1200:0 saved 1200:12
1200m, 16.93V, 32.8C, Start 10:53, expected 155 to 180m 1355to1380m, 12:03-Y, 12:20-O, 12:40-R, 13:40-drained 1367m
167min total 4770 to 4175, 4470adv. (based off face plate calc, not actual usable by Roomba) :handgestures-thumbup:
Min 1370, 14.39V, mAH -1, 48.3C, state 2
Min 1457, 14.06V, mAH 11, 39.9C, state 2
do-charging-on @ minutes 1457
Min 1458, 14.72V, mA 1285, mAH 15, 39.8C, state 5
Min 1642, 17.28V, mA 1260, mAH 3355, 47.9C, state 5
charging-done: dTdt/dTdtf @ minutes 1642
Min 1642, 16.98V, mA 0, mAH 3774, 47.9C, state 6
17.28 - 16.87 = .41V/1.26 = 325mO/12 = 27mO
Last edited by a1robotrepair on January 3rd, 2017, 7:34 pm, edited 15 times in total.
Roses are red Violets are blue Poems are hard Flowers and Chocolate
http://www.daycounter.com/Calculators/
a1robotrepair
Robot Addict
 
Posts: 653
Joined: October 14th, 2013, 8:40 am

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby babakonda » December 30th, 2016, 9:06 pm

Count me in whenever this gets to Europe.
Never. :roll:
babakonda
Robot Groupie
 
Posts: 73
Joined: March 29th, 2016, 5:58 pm
Location: Croatia

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby off-road-biker » December 31st, 2016, 12:16 pm

babakonda wrote:Count me in whenever this gets to Europe.
Never. :roll:

:o There are lots of offers in Amazon!!!
Roomba 560 with 700 ECHM (grey) and modded original vac bin (R3)
User avatar
off-road-biker
 
Posts: 22
Joined: December 30th, 2016, 12:12 am
Location: Germany

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby babakonda » January 1st, 2017, 4:12 pm

Yeah but there are also only 2-3 brands I would trust enough to use their batteries in Roomba, Tenergy being one of them. Which are not available in Europe...
babakonda
Robot Groupie
 
Posts: 73
Joined: March 29th, 2016, 5:58 pm
Location: Croatia

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby Harry007x1 » January 3rd, 2017, 10:52 am

Received a 3500ma and 4500ma pack. Both are very high quality as I've come to expect from other Tenergy products used. The 3500 was installed in my 560 and fit the battery box perfectly. Charged and ran 1st cleaning cycle, unplugging dock until clean light turned yellow, approximately 1.5hrs run time. I expect that to go up slightly after a few charge/discharge cycle. The 4500 pack is a heavy pack, installed in my 770. Fitment was very snug in the battery box, much tighter then expected but did seat and work fine. 1st mission run time was 1:15 and battery was still green. More to come.


Sent from my iPhone using Tapatalk
Harry007x1
 
Posts: 11
Joined: October 26th, 2015, 7:17 am

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby off-road-biker » January 4th, 2017, 4:53 am

Would you please link the two batteries. Thanks!
Roomba 560 with 700 ECHM (grey) and modded original vac bin (R3)
User avatar
off-road-biker
 
Posts: 22
Joined: December 30th, 2016, 12:12 am
Location: Germany

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby hseokman » January 17th, 2017, 7:28 pm

I received high capacity 4500mAh battery. Although 560 is not listed in the high capacity model, but it fits fine and it is very tight fit. I left on the charger over 24 hours and did initial run. It stopped after 116 minutes of running. I will report back after a few cycles.
hseokman
 
Posts: 1
Joined: January 4th, 2017, 3:36 pm

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby etp » January 25th, 2017, 5:46 am

Same here/sign me up for a battery! I assume these will work on the 860?????
etp
 
Posts: 10
Joined: January 25th, 2017, 5:35 am

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby babakonda » January 25th, 2017, 1:51 pm

etp wrote:Same here/sign me up for a battery!


:idea:
Tenergy wrote:If any of you would like to receive this battery for free (U.S. only) and give your Roomba a boost, please PM or email me.
babakonda
Robot Groupie
 
Posts: 73
Joined: March 29th, 2016, 5:58 pm
Location: Croatia

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby litalfoot » January 30th, 2017, 6:50 pm

Got a replacement battery for my Roomba 655 series I robot and it fits perfectly and works great. My original battery wasn't charging and was making a clicking sound when it was docked. This occurred a little after one year of light usage. I called tech support and they told me to get a new docking station which would have cost me $54. I got a replacement battery from Tenergy and now my I robot is working again and charging fine. So before you go out and buy a new docking station; try to switch out the battery first. Tenergy battery works great. I would give it a 5 star. Thanks Tenergy
Lien Lam
litalfoot
 
Posts: 1
Joined: January 4th, 2017, 11:28 am

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby Tenergy » March 17th, 2017, 7:40 pm

Thanks everyone for the feedback! We now have the new lithium Roomba replacement battery open for product focus group. Email us to sign up for a FREE sample!

Tenergy Team
Tenergy
 
Posts: 3
Joined: December 21st, 2016, 10:23 pm
Location: California, USA

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby Harry007x1 » March 19th, 2017, 5:28 am

These batteries have performed flawlessly. Great run times. Look forward to evaluating the lithium.
Harry007x1
 
Posts: 11
Joined: October 26th, 2015, 7:17 am

Re: Replacement Battery for Roomba 500, 600, 700, & 800 Seri

Postby TechGuy » March 28th, 2017, 3:05 pm

Charged my new Tenergy Li-Ion 4400mAh battery overnight without getting charging error 5.
It ran my Roomba 540 for about 2 hours before the CLEAN light turned red.

I will update this post later with long term performance.

2017.03.29 Update:
After the first run, my 540 was back to the home base to re-charge. It was charging fine. I accidentally knock my 540 off the home base after the Li-Ion battery was fully charged. I put it back to the home base. I started to get the charging error 5. According to Tenergy instruction on OP, I have to run my Roomba for 10 minutes before putting my Roomba back on to home base. I think this procedure is not acceptable if owners want to configure their Roomba 560 to run on schedule. The charging error 5 will prevent Roomba from starting on schedule. But this battery may be good for the Roomba 510 owners because 510 can only be charged from the side jack only.
Charging battery directly: 400 Series, 500 Series,. How to Desolder
For Sale: Black CHM 2 Ball Bearings set
User avatar
TechGuy
Robot Addict
 
Posts: 1449
Joined: February 17th, 2009, 11:52 pm


Return to iRobot Roomba and Scooba Chat

Who is online

Users browsing this forum: No registered users and 126 guests